Pipe Jacking

cart (0)
News Category
RASA DHD900 for hard soil and rocks
RASA DHD900 for hard soil and rocks
05 May 2020

This DHD900 pipe jacking machine for pipe OD of 1200mm is specially built with 2 different cutter disks for Aik Leong Plumbing Construction's upcoming pipe diversion projects in Singapore, each with different ground conditions.

First, the normal cutter disk as installed on the DHD900 will be used for excavating hard soil in an LTA sewer diversion project. Upon completion, it will then be replaced with the rock cutter disk for excavating through rock conditions at Pasir Panjang Road / West Coast Drive area, as part of the Deep Tunnel Sewerage System (DTSS) Phase 2 project.

Machine inspection was done earlier in March and machine has arrived in Singapore. Pipe jacking w...

Pipe jacking: A technology breakthrough in underground construction
Pipe jacking: A technology breakthrough in underground construction
20 April 2020

Pipe jacking, also known as microtunneling, has proven to be a real technology breakthrough in underground construction and it is apparent in its increasing popularity among contractors worldwide over the past 30 years.

In essence, pipe jacking is a trenchless method of installing pipelines underneath roads, buildings and more, with minimal disruption to the surface and reduced downtime on its surrounding environment. Apart from manhole works at both ends of the pipeline where the jacking machine is lowered and later removed, most of the works take place beneath the surface.

Based on factors of environmental sustainability and cost savings alone, pipe jacking far outw...

RASA DH1800 for Hong Kong client - Yee Hop Engineering
RASA DH1800 for Hong Kong client - Yee Hop Engineering
24 March 2020

Amidst this COVID-19 situation where travelling is limited for everyone’s safety, we know we can always count on our RASA suppliers in Japan.

Here’s the inspection done by RASA on behalf of our Hong Kong client – Yee Hop Engineering, for the Sai Sha Road Widening Works. The DH1800 machine is all set to go!

Visit our RASA page for more information.

...
RASA DH2500 pipe jacking for hard soil
RASA DH2500 pipe jacking for hard soil
02 March 2020

The team visited RASA factory in Fukuoka, Japan, for another machine inspection with Kingview Engineering! Designed for hard soil conditions, this RASA DH2500 machine is specially built to perform pipe diversion works as part of the Deep Tunnel Sewerage System (DTSS) Phase 2 project.

JK&T Equipment specialises in providing microtunneling equipment to civil engineering companies in Singapore, Malaysia and Hong Kong. Contact us at 6904 5833 or enquiries@jktgroup.com.sg for more information.

...
Slurry management gaining popularity among pipe jacking players
Slurry management gaining popularity among pipe jacking players
04 February 2020

Slurry management is gaining popularity among pipe jacking operators as it provides cost savings and efficiency from treating slurry onsite. For most pipe jacking sites, JK&T recommends a combination of a Desander for separation of large solids and a Decanter Centrifuge to further remove fine solids prior to disposal.

JK&T offers a wide range of Desanders and Decanter Centrifuges, and we can customise our slurry management solutions based on your project needs. Contact us for further discussion at 6904 5833 or enquiries@jktgroup.com.sg

...
RASA DH2000 pipe jacking for rocks and hard soil
RASA DH2000 pipe jacking for rocks and hard soil
16 December 2019

Another RASA DH2000 pipe jacking machine built for rocks and hard soil is arriving in Singapore this January!

Check out the highlights of our joint inspection with client Sam Lain Equipment Services at RASA factory in Fukuoka, Japan. Stay tuned for more updates!

JK&T Equipment specialises in providing microtunneling equipment and parts to civil engineering companies in Singapore, Malaysia and Hong Kong. Contact us at 6904 5833 or enquiries@jktgroup.com.sg today!

...